cart doesnt wanna run

[walker]

I have a G16E that is 36 volt. I just put in new batteries and fully charged them. Every time I press on the accellerator all I get is a click noise. What is the problem?

[thrash]

The click means you're half way down the mountain. Try jumping the big terminals on the solenoid. If it runs then it means you have a bad solenoid.

[shadowman]

lots of people think because the solenoid clicks that its good.........not always............. thrash is right jack the rear end up and jump the large post on solenoid use a peice of 6 gage cable.......while your at it if you put new batteries in make sure you wired it back up right............can,t tell you how many times i have seen that happen, also check all cables to make sure you didn,t forget to tighten one up.....................................

[justme]

I have the same problem . when i jumped it off it sparked . Any help would be great ..

[Michael Eddie]

I have the same problem . when i jumped it off it sparked . Any help would be great ..

Hi Justme, we'll be more than glad to help! Please clarify, it sparked meaning the cart started up?

[lestersboy]

I have the same problem, I jumped the two big terminals on the soliniod and BIG SPARKS, ark flash, big time. I will jump it now like I did on my old Ford soliniods and try it, if it works I"ll get back.

[lestersboy]

BIG BIG SPARKS, I guess I need to dig deeper, new battery's I just installed, but I bought the cart and the guy I purchaced it from said it did run but batteries went dead and the charger took a dump, I repainted the cart and put new trim on it. now I want it to run. Push on the pedal a click but nothing happens.

[Michael Eddie]

BIG BIG SPARKS, I guess I need to dig deeper, new battery's I just installed, but I bought the cart and the guy I purchaced it from said it did run but batteries went dead and the charger took a dump, I repainted the cart and put new trim on it. now I want it to run. Push on the pedal a click but nothing happens.

When you press the gas does the cart click?

[lestersboy]

Yes it clicks when I press the pedal down but the wheels won't turn forward or reverse. When I tried to jump the big terminals with a large screw driver it was ready to weld so I could not test the accelerator pedal. I went to the wiring diagram but I am unable to print it due to a printer problem. I can paint and turn wrenches but I am an admitted idiot with electrical if it is at all complicated. I don't want to send it to a shop and get milked.

[lestersboy]

Yes it clicks when I press the pedal down but the wheels won't turn forward or reverse. When I tried to jump the big terminals with a large screw driver it was ready to weld so I could not test the accelerator pedal. I went to the wiring diagram but I am unable to print it due to a printer problem. I can paint and turn wrenches but I am an admitted idiot with electrical if it is at all complicated. I don't want to send it to a shop and get milked.

I noticed my wires to the back switch and the cut-off switch have been cut and not connected, my problem there is I am having trouble locating those switchs so I can fix that problem, I am stumped.