This article is relevant to all golf carts 1980 - present.
Air Filter
Clean the air filter every 125 hours of use. Replace if very dirty or damaged.
Oil Filter (2-cycle)
Run a visual inspection of filter every month. Replace every year.
Oil Filter (4-cycle)
Clean the oil filter every 125 hours of use. Replace if very dirty or damaged.
Fuel Filter
Replace the fuel filter every 250-300 hours of use.
-
How Often Do I replace the filters on my golf cart?
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I take the governor off an electric Club Car / Ezgo / Yamaha golf cart?
Impossible. Electric golf carts do not have governors. They are only used on gas golf carts to limit how high the engine revs. On electric golf carts the speed is governed by things like the controller and motor.
A lot of the newer golf carts now come with what is called a regenerative "regen" breaking system which slows the cart down when riding on hills. If this feature is annoying to you I have good news, typically it can be modified. Each golf cart has its own different...
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I contact Club Car, Ezgo, Yamaha, Columbia?
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I remove the governor and rev limiter on a gas Club Car?
1984-91 Gas Club Car DS:
Up Shortly.
1992-04 Gas Club Car DS:
To remove the governor - Directly behind the forward facing seat there is a differential access panel (a black plastic cover). Remove the cover and you will now have easy access to the differential.
On top of the differential you will see a gold arm. Remove the bolt that is clamping down the arm to the transmission and put a zip tie on the little spring that is located on the right side of the gold...
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I put my PDS EZGO into diagnostics code mode?
If you have a PDS EZGO (forward/reverse switch on the dash) when in the event of a problem you can enter the golf cart into diagnostics mode to help find out what is wrong with your cart.
To enter diagnostics mode turn the key switch to off, move the run/tow switch to run, move the direction switch from neutral to rev 5 times. The cart will beep to confirm you are in diagnostics mode. After that, the diagnostics code beep will sound if there is a problem. When you are finished move... -
How Often Do I perform a differential oil change?
Perform an oil change on the rear differential every 5 years.
Always check the amount of oil in the differential case yearly. If you find that that the level has dropped, add more of the correct type of oil specified in your owners manual until it is at the correct level also specified in your owners manual.
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I Test An Electric Golf Cart Motor?
There are many types of electric motors, today I will explain how to test the most popular golf cart motors:
Series Wound Motor:
There are 4 connections on the motor, we'll use the following as an example. A1, A2, F1 and F2. The letters could differ. Put a jumper wire from A1 to F1 so they are connected. Now jump the A2 and F2 connections with a 12 volt battery or battery charger. It does not matter which polarity. If the motor is good it will turn over.
Shunt Wound...
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I Dispose Of My Bad Golf Cart Batteries?
You can easily get rid of your scrap batteries, weather you have lead acid rechargeables or just a regular lead acid battery off your gas golf cart. Look in the phone book and chances are you will find a battery supplier or battery refurbishing company. These companies will buy your battery as a core and pay you around $13 per core. Prices change over time so it the amount you get will vary.
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I Find The Production Date On Trojan Batteries?
Stamped into the battery, or on a sticker there will be date codes. Check the date codes to find the production date.
Negative post: Letter and Number - Letter is month, Number is year
eg: C-9 = Mar/2009.
Originally posted by Dougmcp, edited by Mike Eddie
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos. -
How Do I Run 12 Volt Accessories From A 36 Volt Electric Golf Cart?
I have attached a diagram which shows the proper layout. The example layout for the 36v Ezgo.
...
Photos Attached
You do not have permission to view this gallery.
If you are a guest, you may be required to Log In or Sign Up to view.
This gallery has 1 photos.
There are no articles in this category.
Please log in to your account to view your subscribed posts.
